Effect of vibration on the separation efficiency of high-sulfur coal in a compound dry separator | |
Xiaodong Yu; Zhenfu Luoa; Haibin Li; Xuliang Yang; Enhui Zhou; Haishen Jiang; Jida Wu; Shulei Song; Luhui Cai; Zhenfu Luo | |
2016 | |
发表期刊 | International Journal of Mineral Processing |
卷号 | 157页码:195-204 |
摘要 | The direct combustion of high-sulfur coal can cause serious problems such as the formation of acid rain; therefore, the desulfurization of high-sulfur coal before combustion can reduce environmental pollution. On the basis of an analysis of raw coal, the use of a compound dry separator is proposed in this paper to separate high-sulfur coal across the full size range of 80-0 mm. The effects of the vibration amplitude (A), frequency (f), and angle (0) on the separation results were systematically analyzed in this study. The results showed that when the high-sulfur coal was separated using the compound dry separator under the optimal vibration parameters off = 38 Hz, A = 2.6 mm, and theta = 46.5 degrees, the yields of the concentrate and tailings were 71.24% and 28.76%, respectively, with corresponding sulfur contents of 0.93% and 28.59%. The probable error (E) was 0.145 with the largest degree of sulfur content segregation. Under these separation conditions, the acceleration at a clean coal segment increased by 58.06% compared with that at a gangue area; moreover, the material stratification at the clean coal segment was apparent, and the clean coal area was the main separation area. The stratification of dense material at the gangue area was poor, and the gangue area was mainly used to transport and discharge gangue. (C) 2016 Elsevier B.V. All rights reserved. |
文章类型 | Article |
关键词 | Compound Dry Separator High-sulfur Coal Vibration Parameters Desulfurization |
WOS标题词 | Science & Technology ; Technology ; Physical Sciences |
DOI | http://dx.doi.org/10.1016/j.minpro.2016.10.008 |
关键词[WOS] | FLUIDIZED-BED ; FINE COAL |
收录类别 | SCI |
语种 | 英语 |
WOS研究方向 | Engineering ; Mineralogy ; Mining & Mineral Processing |
项目资助者 | National Natural Science Foundation of China(51404244) ; Natural Science Foundation of Jiangsu Province(BK20140209) ; Jiangsu Province postdoctoral research funding schemes(1501058A) ; Jiangsu Province Ordinary university academic degree graduate student scientific research and innovation project(KYZZ16_0226) ; Priority Academic Program Development of Jiangsu Higher Education Institutions |
WOS类目 | Engineering, Chemical ; Mineralogy ; Mining & Mineral Processing |
WOS记录号 | WOS:000390506600025 |
引用统计 | |
文献类型 | 期刊论文 |
条目标识符 | http://ir.qibebt.ac.cn/handle/337004/9202 |
专题 | 热化学转化研究组 |
通讯作者 | Zhenfu Luo |
作者单位 | 中国矿业大学化工学院;(2)中科院青岛生物能源与过程研究所;(3)中国矿业大学机电工程学院 |
推荐引用方式 GB/T 7714 | Xiaodong Yu,Zhenfu Luoa,Haibin Li,et al. Effect of vibration on the separation efficiency of high-sulfur coal in a compound dry separator[J]. International Journal of Mineral Processing,2016,157:195-204. |
APA | Xiaodong Yu.,Zhenfu Luoa.,Haibin Li.,Xuliang Yang.,Enhui Zhou.,...&Zhenfu Luo.(2016).Effect of vibration on the separation efficiency of high-sulfur coal in a compound dry separator.International Journal of Mineral Processing,157,195-204. |
MLA | Xiaodong Yu,et al."Effect of vibration on the separation efficiency of high-sulfur coal in a compound dry separator".International Journal of Mineral Processing 157(2016):195-204. |
条目包含的文件 | 下载所有文件 | |||||
文件名称/大小 | 文献类型 | 版本类型 | 开放类型 | 使用许可 | ||
Effect of vibration (2789KB) | 期刊论文 | 作者接受稿 | 开放获取 | CC BY-NC-SA | 浏览 下载 |
除非特别说明,本系统中所有内容都受版权保护,并保留所有权利。
修改评论